Concrete Polishing & Epoxy Flooring in Etna, OH

Usually, yes. The floor can be densified and polished in zones, often on nights or weekends, while the rest of the building keeps shipping. Racking can stay put. A phased plan gets built at the estimate around your dock schedule.

Yes, a five-year-old slab is fully cured and usually in good shape. It may have early hairline cracks and some oil stains, which get repaired and ground during prep. A moisture test still comes first, then the coating goes on.

A full-broadcast flake epoxy with a polyaspartic topcoat is a strong choice. It seals out brine and has light texture for grip. A squeegee and a rinse every few weeks in winter keep the salt film off, and cove base can protect the wall bottoms too.

Epoxy is usually better there. Battery acid can etch polished concrete, so a chemical-resistant coating gives that zone the protection it needs. The rest of the warehouse can be polished, and the two systems sit side by side without any problem.

A solid color epoxy or a grind-and-seal floor both work well under mats. Epoxy gives you a clean, bright floor outside the mat area. If you drop heavy weights, keep mats over the lifting zone, since any hard floor can chip from impacts.

Marks can still show on a polished floor, but they come off much easier. A guard on the surface keeps rubber from bonding into the concrete, so an auto scrubber removes most of it. Non-marking tires on lifts help too.

Concrete Polish and Epoxy Ohio installs flake epoxy garage floors in Etna's newer subdivisions, where two and three car garages hold slabs with curing compound and early hairline cracks. The finished floor handles winter slush from I-70 commutes and mops clean. Our own crew handles the grinding, crack repair and coating.

Yes, every time. Newer basements usually have a vapor barrier, but testing confirms it and takes little time. If readings are high, a moisture-tolerant primer protects the coating from lifting. Skipping the test is one of the most common reasons basement coatings fail.

It depends on your lease, so check with your landlord. Many landlords like polishing because it improves the building and leaves no coating to remove later. Tenants often pay when they need it for operations. Either way, a written quote helps both sides decide.

Yes. Pop-outs are small cone-shaped holes where aggregate near the surface broke loose. They're filled and ground flush during prep, then the coating goes over them. A flake finish hides the repairs well, so the floor looks even once it's done.